Page images

no intelligent officer who knows much of that gas will be long in removing it as soon as it is generated, and also be constantly prepared for its appearance in the mine when it is known to exist, or even where there is a probability of its existence. The mixed use of Davy lamps and candles in a mine where fire damp is known to be in any part of the workings OT waste, is, to say the least of it, both reckless and dangerous.

A securely locked Davy lamp, with a shield, is a safe instrument in the hands of a careful man, who knows the principles on which it is conStructed. By this I mean that it is invaluable for an intelligent fireman to examine the workings with, before the men are sent into them, and for workmen to use it as a precaution in a well ventilated mine against accidents in the ventilation; but it should never be used as a substitute for ventilation, and in places so full of gas as to have the gauze full of flame. There is no excuse in the world for working with lamps full of flame for any length of time, and if it is persisted in, accidents sooner or later are sure to occur. Often when in a dead place lamps are filled with flame, there being too much fire damp present to make the air explosive, the admittance of a current of air will suddenly dilute the gas to the point of greatest explosion, namely, one of fire damp and seven of air, and a series of explosions will take place in the lamp. It is then said to be very sharp gas, and some practical men think that the mixture contains other gases than fire damp and air, but all investigations up to this time have failed to detect such gases, and I therefore still think that the sharpness arises from its being at the mixture of greatest explosion.

It is very difficult to pass flame through good standard gauze, even the flame of coal

gas containing a considerable amount of olefiant gas, as my experiments now exhibited clearly show; but still flame will pass through gauze saturated with oil and covered with cannel coal dust.

In cleaning lamps which have had coal dust burnt into a cinder on them, it is very difficult to get it off, and in doing so the gauze is sometimes damaged. Accidents occur frequently from damaged gauze, and too great care cannot be bestowed in examining the gauze before the lamp is used.

Before proceeding to the consideration of mining lamps, it will be well to say something on the nature of flame, as all the safety belonging to them depends on their power to prevent flame passing from the inside of the lamp to the outside. Flame, according to Sir Humphrey Davy, "is gaseous matter heated so highly as to become luminous, and that to a degree of temperature beyond the white heat of solid bodies, as shewn by the circumstance that air not luminous will communicate this degree of heat. This is proved by the simple experiment of holding a fine wire of platinum about both of an inch from the exterior of the middle of the flame of a spirit lamp, and concealing the flame by an opaque body, the wire will become white hot in a space where there is no visible light. When an attempt is made to pass flame through a fine mesh of wire gauze, at the common temperature, the gauze cools each portion of the elastic matter that passes through it, so as to reduce its temperature below that degree at which it is luminous, and the diminution of temperature must be proportional to the smallness of the mesh and the mass of the metal. The power of a metallic or other tissue, to prevent explosion, will depend upon the heat required to produce the combustion, as compared with that acquired by the tissue; and the flame of the most inflammable substances, and of those that produce most heat on combustion, will pass through a metallic tissue that will interrupt the flame of less inflammable substances, or those that produce little heat or combustion. Or the tissue being the same, and impermeable to all flames at common temperatures, the flames of the most combustible substances, and of those that produce most heat, will most readily pass through it when heated, and each will pass through it at a different degree of temperature. In short, all the circumstances which apply to the effect of cooling mixtures upon flame, will apply to cooling perforated surfaces."* The same author also states that when rapid currents of explosive mixtures are made to act on wire gauze, it is of course much more rapidly heated; and therefore the same mesh which arrests the mixtures of explosive mixtures at rest, will suffer them to pass when in rapid motion; but by increasing the cooling surface, by diminishing the size or increasing the depth of the aperture, all flames, however rapid their motion, may be arrested." Sir H. Davy, in one of his latest papers, says. “I have had lamps made of thick twilled gauze of wires of 7th of an inch 16 to the warp and 30 to the west, which being rivetted to the screw caunot be displaced; from its flexibility it cannot be broken, and from its strength it cannot be crushed, except by a very strong blow.+ Since the discovery of Sir Humphrey Davy in 1816, when he produced a light enclosed in a cylinder of wire gauze 8 inches high, and not more than 2 inches in diameter, the wire being when twilled not less than oth of an inch in thickness, and 30 in the warp, and 16 to 18 in the weft; and when plain not less than oth of an inch in diameter, and from 28 to 30 both warp and woof, - little has been done in the way of improving it. In common use throughout the United Kingdom, the lamp is pretty much the same as when it came out of the hands of the inventor. For simplicity, utility, and cheapness, the lamp will in the opinion of most practical men be preferred to any yet introduced. The inventor especially cautioned workmen against allowing the gauze cylinder to be heated to dull redness, and moving it against a strong current of air. He saw what we all now know after 30 years' experience, that the locked Davy Lamp with a good shield was a safe instrument in the hands of a careful man who knew the principles on which it was constructed. It never was his idea that it was to be opened and closed, like the door of a common lantern in the open air-placed on the sloping floor of a mine with dry coal-dust on the outside, and oil spilled on the gauze in the inside---moved swiftly against a strong current of an explosive mixture-placed under a falling mass of coal so as to be crushed into all kinds of shapes —or, when injured to have the light extinguished by being blown out;-yet it is well-known that the lamp has been subjected to all these varieties of hard usage, and very unreasonably been expected to prove 6 a safety lamp."

Miscellaneous papers and researches on flame and the safety lamp, p. 73.

Ibid, p. 78.

I shall now proceed slightly to notice several lamps which have been more or less in use:

1st. That invented by the late George Stephenson, a man equally eminent in practical as Sir H. Davy was in theoretical science, and who without doubt produced a mining lamp before the latter philosopher. This lamp in its complete state when it was known in the north by the name of the “Geordie lamp,” was like a common Davy with a wide glass cylinder in the inside and close to the gauze. It is now in considerable use in some parts of South Yorkshire, but it has never been in great use, owing to the glass being liable to break, and from its going out in an impure atmosphere sooner than a Davy. So long as the glass remains entire the lamp must be safer than a Davy, and when broken it must be as good as that lamp; but still the opinion amongst workmen has been that when the glass was broken the lamp was

The gauze

not safe. Its diameter, 2inches, is too much to be thoroughly safe.

2nd. The Upton and Roberts' Lamp. This has the gauze in the inside instead of the outside. Like the Geordie last named it is liable to go out in a foul atmosphere sooner than the Davy. It is a question whether this alleged fault is not a positive advantage, although I know it is strongly objected to by the miners.

3rd. The Solar Mining Lamp. This has never been in general use. It consists in placing a solar lamp in the inside of a common Davy. was of a most dangerous width, being nearly 3 inches in diameter,-a very serious fault with a mining lamp.

4. The Clannys' Lamp. This is a lamp with the gauze placed within the glass. It has come into considerable use in the north, but many parties object to the glass on the outside being liable to be broken, and the light going out in an impure atmosphere.

5. The Muessler, or Belgian Lamp. This is in considerable use in Belgium, but it has not progressed much in England. It is a light simply enclosed in a glass, and consequently not nearly so safe in general use as the lights protected by both glass

and gauze.

I shall now direct your attention to the explosive mixtures of fire-damp. It is a very fortunate circumstance that fire-damp takes a much greater heat to explode it than pure hydrogen, olefiant, or sulphuretted hydrogen gases, or than carbonic oxide. Sir H, Davy found that the ratio of the combustibility of the different gaseous matters was to a certain extent as the masses of the heated matter required to inflame them. Thus, an iron wire of sth of an inch heated cherry red will not inflame olefiant

gas, but it will inflame hydrogen gas; and a

« EelmineJätka »